Control Panel Included with Purchase
Accessories for Amerex Autoclaves Three different types of stainless steel containers of different heights (large, medium and small) are available for handling different loads. Stacking shorter containers can increase load capacity (two medium-sized and three small-sized containers can fit in a given chamber). A mesh wire basket is suitable for most loads, including glassware and media. A pail is used for media and Petri dishes with liquid in them as well as to contain potential spillage from waste bags. A drum has a hinged lid with a handle. Depending on the load, it serves as a closed (but not watertight) trash container or as a carrying and storage case. The side and bottom of the drum are perforated for better steam penetration, sliding panels cover these perforations prior to and after sterilization. Stainless steel tube racks, with various capacities (up to 126 tubes per rack) for 13 mm or 20 mm tubes, are also available. You can stack tube racks by putting them inside stacked containers. Optional accessories also available a) digital temperature and chart recorders, b) data logger and c) floating sensor that monitors the load temperature and sterilization timer are only activated when load temperature reaches set temperature.
AMEATHV-25
AMEATHV-50
AMEATHV-85
AMEATHV-110
Temperature
Operating Range
105º to 126º C
105º to 135º C
Display Range
128° C
137º C
Warming Range
45° to 60° C
Agar Dissolution
Heating at 60º to 100º C for up to 1 hour (temp. and time programmable), followed by 45º to 60º C (programmable for up to 20 hours to prevent coagulation)
Gauge Pressure
3 to 22 psi (0.02 to 148 MPa)
3 to 30 psi (0.02 to 206 MPa)
3 to 30 psi (0.21 to 0.02068 MPa)
Maximum Allowable
27 psi (0.186 MPa)
38 psi (0.26 MPa)
Timer
Sterilization
1 to 250 minutes
Delayed Auto-Start
Program Autoclave to start 1 minute to 7 days later
Dimensions
Overall (W x D x H)
19 x 18 x 37.4 inches, 48 x 46 x 95 cm
20 x 21 x 41 inches, 51 x 53 x 104 cm
26 x 25.6 x 39.4 inches, 66 x 65 x 100 cm
26 x 25.6 x 46.5 inches, 66 x 65 x 118 cm
Chamber (D x H)
25 litres, 9.4 x 21.6 inches, 24 x 55 cm
50 litres, 11.8 x 28 inches, 30 x 71 cm
85 liters, 16.5 x 24.2 inches, 42 x 61.5 cm
110 liters, 16.5 x 31.3 inches, 42 cm x 79.5 cm
Safety Devices
Dual-sensing lid interlock, over-pressure power cutoff, over-temperature power cutoff, low-water power cutoff, mechanical pressure relief valve, microprocessor-controlled pressure relief valve, lid-closure detector, over-current detector and circuit breaker
Programs
1. For Agar
Heating -> Sterilization -> Exhaust (from no exhaust to slow, programmable) -> Warming -> Completion
2. For Liquids
Heating -> Sterilization -> Exhaust (from no exhaust to slow, programmable) -> Completion
3. For Solids
Heating -> Sterilization -> Exhaust (fast, default) -> Completion
4. For Melting Agar or faster Start-Up
Rapid melting at 60° C to 100° C (temperature and time programmable) -> Maintain at 45° to 60° C (temperature programmable) -> Completion
Accessories
Stainless Steel
Mesh wire baskets, buckets (pails), and test tube rack
Factory or Field Installed
Floating (load) Sensor, Auto Water Supply Unit & Digital Printer
Floating (load) sensor, digital printer, and data logger
Power
Source
120 V, 50 / 60 Hz, (220 V / 240 V available on request)
208/220/240 V, 50/60 Hz, Single Phase
Consumption
1,500 Watts (1,500 VA)
2,000 Watts (2,000 VA)
3,000 Watts (3,000 VA)
4,000 Watts (4,000 VA)
Shipping Weight
160 lb, 73 kg
180 lb, 82 kg
282 lb, 128 kg
308 lb, 140 kg
Warranty
1 Year
Equipment 